The content, requirements and procedures of the Trailed Boom Lift
Wear labor protection equipment before driving the crank arm lift, and strictly implement the road traffic management regulations.
Strictly implement the "three inspection system", carefully check the cheery picker according to the daily inspection content, install snow chains on the ice and snow roads as required, and leave no faults:
Perform a comprehensive pre-shift inspection. The oil and water must meet the specified requirements. The brakes, steering, lights, horns, tire pressure, outriggers, hydraulic system, lifting device screws and pins must be locked, and the vehicle fire extinguisher must be in good condition. Check Whether it is intact and deal with any problems in time.
The power take-off can only be used when the hydraulic system needs to work, and must be disconnected before the vehicle is driven.
When the boom lift is carrying out lifting operations, pay attention to the working conditions of the hydraulic oil tank pressure gauge and various mechanisms. If there is any abnormality, stop and check immediately.
After receiving the folding arm car, tighten the handbrake and turn off the power. And conduct a comprehensive inspection and maintenance to meet the safe operating conditions of the successor.
It is forbidden to drive boom lift while drunk, and it is forbidden to drive by non-drivers or non-workers.
Start and stop boom lift smoothly.
Before starting, entering and leaving the warehouse, factory door, and turning on, turn on the turn signal, honking the horn to warn, and confirm that it is safe before driving.
During the driving of the cheery picker, it is forbidden to wear slippers, smoke, answer calls with mobile phones, listen to headphones, chat, diet and other bad behaviors that endanger driving safety.
When passing an intersection, slow down in advance, strengthen lookout, and rush to the road is strictly prohibited.
It is strictly forbidden to slide in neutral gear or stall on a steep slope. Don't brake suddenly without special circumstances. When passing through slopes, muddy roads or wetlands after raining, you should drive slowly at low speeds, avoid shifting, braking and rapid acceleration, and don’t drive near the roadside or ditches to prevent sideslip and rollover.
When parking on a ramp, tighten the handbrake, park downhill with reverse gear, and park uphill with first gear, and plug the tire with a triangular wooden wedge.
